Energy Audit: Hot tubs and Shortcut Return Air Ducts

Energy Audit: Now Recommendations for Energy Saving Up-dates

by Don Ames,   www.detectenergy.com

Now that we have the hot tub and the hole-in-the-wall under control, it is time to go ahead with the rest of the energy audit. Like I pointed out in the previous article about this home, I have connected the old family freezer and the yard-sell green refrigerator to a Kill a Watt monitor. I will leave the monitor in place several days, I am looking forward to returning to the home so I can gather the data from the monitor about old appliance energy usage.

After dealing with the hot tub, the hole-in-the-wall, and two appliances, I have other things on my energy audit list to evaluate. The thing is, these folks have about $3,500 to spend on energy efficiency and I need to help them decide what up-grades and retrofits make the most sense.

Other Appliances:

I find that besides the freezer and green refrigerator they have in the entrance addition, they have 4 more major appliances.

1.  The kitchen refrigerator

- appears fairly new. A sticker on the outside of the door and a sticker inside the door, both indicate that this refrigerator was Energy Star qualified when it was manufactured. It may not meet current Energy Star standards, but replacing it with a new refrigerator would not appear to increase energy efficiency by a significant amount. The refrigerator is safe, I can't recommend replacement.

Efficient Washer & Dryer

2.  The dishwasher

- is also Energy Star rated. I like the little Energy Star stickers. Dishwasher is safe, can't recommend replacement.

3.  The Clothes washer

- is a front load, push button model with energy efficiency written all over it. I don't know what happened to the Energy Star sticker, but it should have been there somewhere. I write down the model number and go to the Energy Star website and find that it is listed as an approved Energy Star model. The clothes washer is safe.

4.  The Clothes Dryer

- matches the clothes washer, they are a set. An electric clothes dryer has a couple options concerning energy efficiency that are important. One is the automatic drying cycle - so the dryer will shut itself off when the clothes are dry, and the other is the exhaust duct. If the exhaust duct becomes restricted, drying time increases and so does energy consumption.

I question the homeowner about drying times and using the auto-dry feature. I look behind the dryer to see if the dryer duct is pinched, damaged, or disconnected. I also go outside and inspect the exhaust hood for lint build up and flapper valve function. All seems well, the dryer is safe.

DEA Was Here

The Blower Door Test:

I am getting pretty good at setting up the blower door, just takes me a few minutes. I like setting it up in the front door of a home   that is in town, it looks like the DEA is performing a drug bust or something. People have told me later that the neighbors were real curious about what was going on.

Before turning on the fan and sucking air out of the house, I make sure the wood stove door is shut and secure, I close and latch all the windows and exterior doors, and open all interior doors. I turn the furnace off and pull the furnace filter out.

The blower door indicates the home is leaking at a rate of about 3.8 air changes per hour. I notice considerable draft coming from the floor heating registers. Since the recognized healthy rate concerning air changes per hour is 3.5, I realize that I cannot safely air seal the home and make it much tighter.

The air coming from the heating registers concerns me, next is the duct blaster test.

Duct Blaster Tools

The Duct Blaster Test:

The duct blaster takes a little longer to set up since all the heating vents need to be taped or sealed. The heating vent that is under the two ton entertainment center is a challenge, I finally find a large heavy book and slide it over the top of the vent.

In this house, I don't want to forget about the short cut return air duct cut into the side of the wall. It will need to be sealed also. Cranking up the fan on the duct blaster I find that total duct leakage is 480 cubic feet per minute. The 480 CFM is gross leakage, what I really want is net leakage, or leakage to the outside of the home.

By using the blower door and the duct blaster together, I can separate the duct leakage into two parts. I am most interested in the amount of air that is leaking out of the heating ducts and is lost to the great outdoors.

I warn the homeowners that things are going to get a little noisy and a little breezy - I crank up both fans. The leakage to outside the home is 320 CFM. I like this figure, 320 CFM it is high enough that I have something to work with that can definitely same energy.

Final Recommendations:

After putting away all my equipment, I sit down with the homeowners, get out my paperwork, and discuss specific recommendations on how they can best use about $3,500 to make their home more energy efficient and more comfortable.

Sealing heating Ducts

1.  Seal the Heating Ducts

Fortunately, this home is serviced by a power company that provides incentives for duct sealing in manufactured homes. I will arrange for a certified duct sealing contractor to seal the ducts in this home and it won't cost the homeowner a penny. A good duct sealing contractor should be able to lower the duct leakage to under 100 CFM.

2.  Insulation and Air Sealing

I will recommend that the floor in the two room addition is air sealed then insulated. There is good crawl space under the floor - I estimate this will cost about $650.

3.  Addition of a Heat Pump

The lady of the house is having additional problems with asthma. When she has an attack, the wood stove is not used and the electric furnace takes over - this is happening more frequently. With aging, keeping the wood pile stocked is not as much fun as it used to be.

By installing a heat pump, they will have more efficient heating and they will have efficient, whole house cooling. I estimate that adding a heat pump to this home will cost about $2,800.

Well, I am going say goodbye to this house for now. I still look forward to checking the Kill a Watt meters in a few days to see how much electricity that freezer and green refrigerator is adding to the electric bill. The next step will be to schedule the duct sealing and to get a couple bids on installing a heat pump and having the underfloor area sealed and insulated. Feeling pretty good about what I have accomplished, I head on down the road.

Unfortunately, I have to drive through the wonderful recycling center on my way out. What a mess, both sides the road too.

Thank you for stopping by Detect Energy, hope you will come back soon, but I won't leave the light on for you...

More from Don Ames and Detect Energy at www.detectenergy.com

Views: 341

Tags: audit, conservation, efficiency, electricity, energy, energy audit, weatherization

Comment

You need to be a member of Home Energy Pros to add comments!

Join Home Energy Pros

Comment by Stan Kuhn on March 19, 2012 at 10:26am

Don, I can't imagine getting pricing like that in my area, but great.  I did pick up on the picture of the blower door.  Interesting comments about the interest.  I like to watch the passers-by react to it; maybe a huge "CAUTION" with arrow, and "Call for further description" would bring some jobs :)  I enjoy your posts, thank you.

Comment by Don Ames on March 19, 2012 at 8:57am

Stan,  I showed a picture of a blower door in a larger stick built home and probably should not have for this article.  Don

Comment by Don Ames on March 19, 2012 at 8:56am

Hi Stan, recently had a 2.5 ton Intertherm heat pump added to a manufactured home, 14 SEER, 12.7 EER, 8.5 HSPF, complete for $3,217.00.  Not including electrical disconnect. It did include a Honeywell 9000 thermostat. For this article and the $2,800, I took into account that the home is smaller and would use a 2 ton unit. I think the $2,800 is pretty close.  In order to get a rebate the heat pump would need to be 16 SEER or better, so no rebate was involved.  Thanks,  Don Ames

Comment by Stan Kuhn on March 19, 2012 at 8:27am

I'm interested in that $2800 heat pump; is the cost subsidized or is a nice rebate included in the pricing?

Home Energy Pros

Home Energy Pros was founded by the developers of Home Energy Saver Pro (sponsored by the U.S. Department of Energy,) and brought to you in partnership with Home Energy magazine.

Latest Activity

Jim Gunshinan commented on Jim Gunshinan's blog post Energy Upgrade California—Up Close and Personal
"I had a revelation while attending Bruce Manclark's session of duct leak testing at the Energy…"
10 hours ago
George J. Nesbitt commented on Jim Gunshinan's blog post Energy Upgrade California—Up Close and Personal
"Blower Door; the 2007 test was a depressurization test, and the 2014 a pressurization test, which…"
10 hours ago
George J. Nesbitt replied to Kaushal Bharath Raju's discussion Affordability & Deep Energy Upgrade/Passive House Retrofit in Berkeley, California.
"Plan, plan, plan, plan. The 1st step to is to understand the house, how it's built, the…"
10 hours ago
George J. Nesbitt posted an event

High Performance Windows - A Panel of Experts at Pyramid Alehouse`

April 26, 2014 from 3pm to 5pm
Join a lively panel discussion on high performance windows. We'll cover some basics, as well as…See More
11 hours ago
Kaushal Bharath Raju replied to Kaushal Bharath Raju's discussion Affordability & Deep Energy Upgrade/Passive House Retrofit in Berkeley, California.
"Hi David, Thanks for pointing out Martin Holiday's article. I do not wish to engage in the…"
11 hours ago
Profile IconAdam Penberthy, Scot Davidson and j jarvella joined Home Energy Pros
12 hours ago
David Eakin replied to Kaushal Bharath Raju's discussion Affordability & Deep Energy Upgrade/Passive House Retrofit in Berkeley, California.
"More food for thought on this subject - read this (fairly) recent blog by one of the most respected…"
17 hours ago
Curt Kinder commented on Christopher Morin's blog post 5 Things New Energy Efficiency HVAC Contractors Need to Know
"You left out air distribution...Without at least a passing glance at how much air moves through the…"
23 hours ago
David Eakin replied to Kaushal Bharath Raju's discussion Affordability & Deep Energy Upgrade/Passive House Retrofit in Berkeley, California.
"I mis-spoke - I was referring to the Midori House in Santa Cruz. Have an in-depth discussion with…"
yesterday
Kaushal Bharath Raju replied to Kaushal Bharath Raju's discussion Affordability & Deep Energy Upgrade/Passive House Retrofit in Berkeley, California.
"Hi David & Bud, $400/sqf > $300 sqf. The latter is the minimum cost of new construction in…"
yesterday
David Eakin replied to Kaushal Bharath Raju's discussion Affordability & Deep Energy Upgrade/Passive House Retrofit in Berkeley, California.
"Kaushal, There was a deep energy retrofit upgrade project (to Passive House standards) in San Jose…"
yesterday
Kim Tanner updated an event

Beyond Residential Testing at The Energy Conservatory

May 14, 2014 to May 16, 2014
The Energy Conservatory (TEC) is hosting a Beyond Residential Testing event. In addition we are…See More
yesterday

© 2014   Created by Lawrence Berkeley National Laboratory.

Badges  |  Report an Issue  |  Terms of Service